Broan EW5836SS Installation Manual download pdf

Chimney

ange cod

BmeAm+

MODELS EW5830SS ,, EW5836SS

Page I

WARNING

FOR DOMESTIC

TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR iNJURY

TO PERSON(S) OBSERVE THE FOLLOWING:

1. Use this unit only in the manner intendedby the manufacturer. If

you have questions, contact the manufacturer at the address or

telephone number listed inthe warranty.

2. Before servicing or cleaning unit, switch power off at service panel

and lock service disconnecting means to prevent power from being

switch on accidentally. When the service disconnecting means

cannot be locked, securely fasten a prominent warning device,

such as a tag, to the service panel.

3. Installation work and electrical wiring must be done by qualified

personnel in accordance with all applicable codes and standards,

includingfire-rated construction codes and standards.

4. Sufficient air is needed for proper combustion and exhausting

of gases through the flue (chimney) of fuel burning equipment to

prevent back drafting. Followthe heating equipment manufacturer's

guideline and safety standards such as those published by the

National Fire Protection Association (NFPA), and the American

Society for Heating, Refrigeration and Air Conditioning Engineers

(ASHRAE), and the local code authorities.

5. This product may have sharp edges. Be careful to avoid cuts and

abrasions during installationand cleaning.

6. When cutting or drilling intowall or ceiling, do not damage electrical

wiring and other hidden utilities.

7. Ducted fans must always be vented to the outdoors.

8. Use only metal ductwork.

9. Do not use this unit with any other solid-state speed control device.

10. Do not operate any fan with a damaged cord or plug. Discard fan or

returnto an authorized service facility for examination and/or repair.

11.GROUNDING INSTRUCTION: The appliance must be grounded.

In the event of an electrical short circuit, grounding reduces the risk

of electric shock by providing an escape wire for the electric current.

The appliance is equipped with a cord having a grounding wire with

a grounding plug. The plug must be plugged intoan outlet that is

properly installedand grounded. WARNING: improper grounding

can result in a risk of electric shock. Consult a qualified electrician

if the grounding instructions are not completely understood, or if

doubt exists as to whether the appliance is properly grounded. Do

not use an extension cord. If the power supply cord is too short,

have a qualified electrician installan outlet near the appliance.

TO REDUCE THE RiSK OF A RANGE TOP GREASE FIRE:

a) Never leave surface units unattended at high settings. Boilovers

cause smoking and greasy spillovers that may ignite. Heat oils

slowly on lowor medium settings.

b) Always turn hood ON when cooking at high heat or when flamb_ing

food (i.e. Cr_pes Suzette, Cherries Jubilee, Peppercorn Beef

Flamb_).

c) Clean ventilating fans frequently. Grease should not be allowed to

accumulate on fan or filters.

d) Use proper pan size. Always usecookware appropriate for the size

of the surface element.

COOKING ONLY

WA.NING

TO REDUCE THE RiSK OF iNJURY TO PERSON(S) iN THE EVENT

OF A RANGE TOP GREASE FIRE, OBSERVE THE FOLLOWING*:

1. SMOTHER FLAMES with a close-fitting lid, cookie sheet, or metal

tray, then turn off the burner. BE CAREFUL TO PREVENT BURNS.

IF THE FLAMES DO NOT GO OUT IMMEDIATELY, EVACUATE

AND CALL THE FIRE DEPARTMENT.

2. NEVER PICK UP A FLAMING PAN- You may be burned.

3. DO NOT USE WATER,includingwet dishcloths or towels- a violent

steam explosion will result.

4. Use an extinguisher ONLYif:

A. You know you have a Class ABC extinguisher, and you

know how to operate it.

B. The fire issmall and contained inthe area where it started.

C. The fire department is being called.

D. You can fight the fire with your back to an exit.

* Based on "Kitchen Fire Safety Tips" published by NFPA

CAUTION

1. For indooruse only.

2. For general ventilating use only.Do not use to exhaust hazardous

or explosive materials and vapors.

3. To avoid motor bearing damage and noisy and/or unbalanced

impeller,keep drywall spray, construction dust, etc. off power unit.

4. Your hood motor has a thermal overload which will automatically

shut off the motor if it becomes overheated.The motor will restart

when it will cool down. If the motor continues to shut off and

restart, have the hood serviced.

5. The bottom of the hood MUST NOT BE LESS than 24" and

recommended at a maximum of 36" above cooktop for best

capture of cooking impurities.

6. Two installers are recommended because of the size of this

hood.

7. To reduce risk of fire and to properly exhaust air, be sure to duct

air outside. Do not exhaust air intospaces within wails or ceilings

or into attics, crawl spaces, or garages.

8. Becareful when installingthe decorative flue and hood, they may

have sharp edges.

9. This hood is not intended to be used as a shelf.

10. Please read specification label on product for further information

and requirements.

- Register your product online at: www.broan.com

Installer: Leavethis manual

with the homeowner.

Homeowner:Operationand Maintenance

instructionson pages7 & 8.

1 2 3 4 5 6 ... 27 28

Summary of Contents

Page 1 - COOKING ONLY

Chimneyange codBmeAm+MODELS EW5830SS ,, EW5836SSPage IWARNINGFOR DOMESTICTO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR iNJURYTO PERSON(S) OBSERVE THE

Page 2 - T '

BR N_ Pago 10ilotte de cuisinecheminPOUR USAGE DOIVlESTIQUE SEULEIVlENTAVE.TISSEME.TA AVE.TISSEME.T&AFINDERE_DUIRELESRISQUESD'INCENDIE,DEDISC

Page 3 - ... _-+_

Page 11MESURES DE L'INSTALLATIONPRI_PARATION DE LA HOTTECAPUCHON DE TOIT/-. co oE O.OCONDUIT ROND_"'""_--T'_ '&apos

Page 4 - (Ducted Hoods Only)

Page 12INSTALLATION DU CABLAGEINSTALLATION DU SUPPORTDE MONTAGE DE LA HOTTELIGNEDEpa)\\\\\\\\\\INSTRUCTIONS DE MISE _, LA TERRECet appareil dolt 6tre

Page 5 - + (Non-Ducted Hoods Only)

Page 13INSTALLATION DE LA HOTTE(hottes avec conduits seulement)Centre dePlafond\ I'instaJJation\ ' /\ / ..,o.0..,o,oo0Fentes de Ja bride de

Page 6 - °,,.ou.op.E.uMI

Page 14INSTALLATION DE LA HOTTE(hotte sans conduits seulement)10. GlJssez la section sup6rieure du conduit d6coratif dans sasection inf6rieure.REIVIAR

Page 7 - OPERATION

Page 15CAISSONNON L,----,CANAUS#: ICONDUIT RONDDE IVlE_TAL LONGUEURDE 15 cm (6 po) DU CONDUIT0c%u, ;6. Alignez les deux trous de serrure ext6rieurs de

Page 8 - CLEANING & MAINTENANCE

Page 16FONCTIONNEMENTMettez toujours la hotte en MARCHE avant de cuisiner afin d'6tablirune circulation d'air dans la cuisine. Laissez la ho

Page 9 - WARRANTY

Page 17NETTOYAGE ET ENTRETIENPour des raisons de sant& de performance et d'apparence, net[oyezle filtre, le ventilateur et les surfaces grais

Page 10 - ATTENTION

BR NPII CES DE RECHANGE Page18N° DE N ° DE PIECE DESCRIPTION QTE_REPERE1 S99527475 Conduits d6coratifs sup6rieur 1et inf6rieur2 S99527443 Ensemble mot

Page 11 - -. co oE O.O

Campanapara chimeneaMODELOS EW583OSS ,, EW5836SSgina 19SOLAIVlENTE PARAADVERTENClAPARAREDUCIRELRIESGODEINCENDIOS,DESCARGASELC:CTRICASOLESIONESPERSONAL

Page 12 - ... i ;

BReANMODELS EW5830SS ,, EW5836SSPage 2MEASURE THE INSTALLATIONROOF CAP/ROUND ELBOWJ////////////////////////////////-_/-_/_ _ ._ WALL CAPDECORATIVE FLU

Page 13 - \ / ..,o.0..,o,oo0

BReANMODELOS EW5830SS ,, EW5836SSP_gina 20MIDA LA INSTALACIONPREPARE LA CAMPANA_ TITAPA DE TECHO/CODO REDONDO__ID_/__ _ / TAPA DE PARED1 -- SOPORTE PA

Page 14 - INSTALLATION DE LA HOTTE

BmeAm+iVlODELOS EW5830SS ,, EW5836SSP_gina 21INSTALE EL CABLEADO INSTALE EL SOPORTEDE MONTAJE DE LA CAMPANA/.24 ptll 9_1 Cm) MAX\\\\INSTRUCCIONES PARA

Page 15 - CAISSONNON L,

BReANIVIODELOS EW5830SS • EW5836SSP4gina 22INSTALE LA CAMPANA(s61o en campanas con conductos)Centro de JaCielo raso\ instaiaci6n\ ' /\Ranuras del

Page 16 - ¢ _i VOYANTS DEE _

BReANMODELOS EW5830SS ,, EW5836SS10. Deslice la secci6n superior del tubo de humos decorativo en lasecci6n inferior.NOTAPara aplicaciones con conducto

Page 17 - NETTOYAGE ET ENTRETIEN

BReANMODELOS EW5830SS ,, EW5836SSP4gina 24PLENO PARA } JSISTEMAS SiN ---'_''"__CONDUCTOS ICONDUCTOMETALICO LONGITbDFLEXIBLEREDONDO

Page 18 - GARANTIE

BReANFUNCIONAMIENTOENCIENDA siempre la campana antes de comenzar a cocinar, conel fin de establecer un flujo de aire en la cocina. Despu6s de apagarla

Page 19 - ADVERTENClA

BReANLIMPIEZA Y MANTENIMIENTOPor motivos de desempeSo, apariencia y salud, limpie el fiitro, elventilador y las superficies que tengan grasa. Utiiice

Page 20 - INSTALE LOS CONDUCTOS

BReANiVIODELOS EW5830SS,, EW5836SSPIEZAS DE SERVICIO P gina 27CLAVE PIEZA N.-°1 S995274752356789lO11S99527443S99527444S99527445S99527446S99527448S9952

Page 21 - ... +-+_-... i

Page / P_gina 2899527440C

Page 22 - \ ' /

BReANMODELS EW5830SS • EW5836SSPage 3INSTALL THE WIRING INSTALL THE HOOD MOUNTINGSUPPORTHOoD___CENTERLINEMAX.\\_ 12-\\\GROUNDING INSTRUCTIONSThis appl

Page 23 - (s61o para campanas para

BmeAm+MODELS EW5830SS ,, EW5836SSPage 4INSTALL THE HOOD(Ducted Hoods Only)Center ofCeiling\ installation/+\+-/Upper flue mounting the ceilingbracket s

Page 24 - :1

BmeAm+MODELS EW5830SS ,, EW5838SSPage 5INSTALL THE HOOD+ (Non-Ducted Hoods Only)10. Slide the upper decorative flue section into the lowerdecorative f

Page 25 - ® @,.O,CAOO ESOE

BmeAm+MODELS EW5830SS ,, EW5836SSPage 6°,,.ou.op.E.uMIFLEXIBLEMETAL DUCT DUCT LENGTHDECORATIVE --_FLUE _'t6. Align the two outer keyhole slots on

Page 26 - LIMPIEZA Y MANTENIMIENTO

BReANMODELS EW5830SS,, EW5836SSPage 7OPERATIONAlways turn the hood ON before cooking inorder to establish an airflow in the kitchen. After turning off

Page 27 - GARANTiA

BReANMODELS EW5830SS ,, EW5836SSPage 8CLEANING & MAINTENANCEFor performance, appearance, and health reasons, clean filter, fanand grease-laden sur

Page 28 - Page / P_gina 28

BReANMODELS EW5830SS ,, EW5836SSSERVICE PARTS Page9KEY PART NO.1 S995274752 S995274433 S9952744456789lO11121314S99527445S99527446S99527448S99527449S99